AUTOHELM ST3000 Service Manual download pdf

ST3000 Autopilot

ST3000 Autopilot Service Manual 83004-2 1

Warning

CE Marking of Equipment/Replacement Parts

If the Autohelm equipment under repair, test, calibration, installation or setting to work carries the European CE mark,

only parts and components supplied or approved for such use by Raytheon should be used in order to maintain

compliance with the relevant CE requirements.

Incorporation, use or attachment, by any means, of parts or components not supplied for or not approved for such use by

Raytheon or, if supplied or approved for use by Raytheon, not properly fitted in accordance with instructions published,

provided or recommended by Raytheon, may cause the equipment to malfunction and, in particular, to become unsafe or

to no longer meet the relevant CE requirements. In these circumstances, Raytheon Marine Europe Ltd excludes liability

to the fullest extent permissible in law for any loss or damage including any liability for its contribution to such loss or

damage by its negligent acts or omissions .

Z155, ST3000 Autopilot

Service Manual

D296

1 2 3 4 5 6 ... 11 12

ST3000 AutopilotST3000 Autopilot Service Manual 83004-2 1WarningCE Marking of Equipment/Replacement PartsIf the Autohelm equipment under repair, t

ST3000 Autopilot10 ST3000 Autopilot Service Manual 83004-2Chapter 5. PCB DetailsD4108-1Figure 4: Circuit Diagram

ST3000 AutopilotST3000 Autopilot Service Manual 83004-2 11PCB LayoutD4105-1Taken from Drawing No: 4155-010 Issue: J Date: 07.03.97 Figure 5:

ST3000 Autopilot12 ST3000 Autopilot Service Manual 83004-2PCB Component listD4106-1Taken from Drawing No: 4155-010 Issue: J Date: 07.03.97 R

ST3000 Autopilot2 ST3000 Autopilot Service Manual 83004-2Chapter 1. Before DismantlingBefore dismantling the autohelm ST3000 check the phase of

ST3000 AutopilotST3000 Autopilot Service Manual 83004-2 3Chapter 2. Special FunctionsDisplay testA display test feature included in ST3000 softwa

ST3000 Autopilot4 ST3000 Autopilot Service Manual 83004-2Chapter 3. Functional TestOverall functionChange motor.Restart.Change faultyitem(s). Re

ST3000 AutopilotST3000 Autopilot Service Manual 83004-2 5Fluxgate compass assemblyRemove the fluxgate assembly (see Figure 2).The compass can be c

Page 9

ST3000 Autopilot6 ST3000 Autopilot Service Manual 83004-2Chapter 4. Disassembly/AssemblySeaTalk Deck PlugScrew (x2)Pin carrierPlug pin screw (x3

ST3000 AutopilotST3000 Autopilot Service Manual 83004-2 7Notes:A. Keypads come bonded to facia on later units.B. Ensure that the fluxgate loom is

ST3000 Autopilot8 ST3000 Autopilot Service Manual 83004-2ST3000 Drive ActuatorSpare parts listThe item numbers refer to Figure 3: ST3000 Autopil

ST3000 AutopilotST3000 Autopilot Service Manual 83004-2 9D4102-1PipBlue(M2)Brown(M1)Blue(M2)Brown(M1)Reddot1 2 3 4 5 768 9 1017 16 15111213141. Pi

No comments

AUTOHELM ST3000 Service Manual